卷材屋面施工工程安全作業交底.doc

內容摘要：
1、 裝卸、搬運、熬制、鋪涂瀝青，必須使用規定的防護用品。所有參加瀝青工作的人員必須穿工作服、戴手套、穿翻毛皮鞋并有帆布護蓋等，使皮膚不和瀝青接觸。
2、 熬制瀝青的地點不得設在電線的垂直下方，一般應距離建筑物25m以外。瀝青、燃料的堆放場地，離鍋不小于5m。
3、 熬油前應清除鍋內雜質和積水。
4、 熬油必須有人看守，熬油量不得超過鍋容量3/4。下班熄火，一定要將余火熄滅，關閉爐門，蓋好鍋蓋。
5、 鍋內瀝青著火，應立即用鐵板蓋住，停止鼓風，封閉爐門，熄滅爐火。嚴禁向燃燒的瀝青澆水，應用干砂或濕麻袋滅火。
6、 裝運瀝青的勺、桶、壺等工具，不得用焊錫，盛油量不得超過容器的2/3。肩挑或手推車，道路要平坦暢通，跳板要支牢，要有防滑措施，繩具要結實。垂直運輸時附近12m范圍內禁止站人，屋面上的油桶、油壺必須放置平穩。
7、 屋面鋪貼卷材，四周應設置1.2m高的圍欄，如遇斜屋面周邊防護的高度視坡度增高，靠近屋面四周沿邊應側身操作。
8、 遇六級以上大風時，應停止操作。
9、嚴禁操作人員在酒后進入施工現場作業。
10、每個工人進入施工現場都必須頭戴安全帽。
11、班組如果因勞力不足需要再招新工人時，應事先向工地報告。
12、新工人進場后應先經過三級安全交底，并經考試合格后方可讓其正式上崗。
13、新工人進場應具有四證，即：職業資質證、身份證、計劃生育證和外來人口暫住證
Abstract:
1, loading and unloading, handling, goats, laying asphalt coating, must use the prescribed protective equipment. All participants must wear asphalt work clothes, gloves, clothing and shoes and a canvas cover Fanmao, so that contact with the skin does not and asphalt.
2, endures the asphalt where no bottom in the vertical wires, buildings should generally be 25m from the outside. Asphalt, fuel stack space, away from the pot is not less than 5m.
3, boil remove the pan before the oil impurities and water.
4, boil the oil must be guarded, shall not exceed the pot boil oil capacity of 3 / 4. Flame work, be sure to extinguish embers, close the door, cover the lid.
5, pitch pan fire, immediately cover with iron to stop the blast, closed door, put out the fire. Prohibited the burning of asphalt watering, application of dry sand or wet sacks fire.
6, loading asphalt spoon, barrels, pots and other tools, should not use solder, amount of fuel container shall not exceed 2 / 3. Loaded or cart, flat road to smooth, firm springboard to branch, to have anti-slip, with a rope to be strong. Near the 12m vertical transportation of people within the prohibition of station, the roof on the drums, oiler must be placed stationary.
7, paving roofing membrane, shall be installed around 1.2m high fence around the protection in case of inclined roof height increased as the slope, near the border should be sideways action around the roof.
8, case of 6 or more wind, it should stop.
9, is strictly prohibited operators in the drink to the construction site work.
10, each worker entering the construction site must be wearing helmets.
11 team if the need to move because of a labor shortage of new workers, the report shall be submitted to the site.
12, after the admission of new workers should go through three security correspondent, and pass the examination before they can let the official posts.
13, the new approach should have four cards of workers, namely: professional qualification certificate, identity cards, birth certificates and residence permits
 

前往下載